作者：胡溧, 杨航, 杨啟梁, 王博

作者单位：武汉科技大学汽车与交通工程学院, 湖北 武汉 430065

关键词：变速箱;模态;声品质;客观评价;主观评价

摘要：

为对变速箱箱体共振时的噪声声品质进行评价，通过参考语义细分法的主观评价和计算声品质客观参量建立变速箱模态共振工况下的声品质评价模型。结合多种主观评价试验方法优缺点，采用改进的参考语义细分法。选取主要的声品质客观参量进行计算，试验数据表明，在371 Hz、460 Hz和492 Hz等低阶共振频率激励下，变速箱箱体产生噪声的响度较高，尖锐度、波动度和粗糙度较相对较低，但烦躁度值相对较高。在652 Hz和813 Hz共振频率激励下，噪声引起的烦躁度值较低。

Sound quality evaluation of a gearbox in resonance
HU Li, YANG Hang, YANG Qiliang, WANG Bo
School of Automobile and Traffic Engineering, Wuhan University of Science and Technology, Wuhan 430065, China
Abstract: In order to evaluate the sound quality of gearbox during resonance, the sound quality evaluation model of the gearbox under resonance mode is established by the subjective evaluation of the reference semantic subdivision method and the objective parameters of the sound quality. Combined with the advantages and disadvantages of various subjective evaluation methods, an improved reference semantic subdivision method is adopted. The main objective parameters of sound quality are selected for calculation. The test data shows that the loudness of noise generated by gearbox housing is higher, and sharpness, fluctuation strength and roughness are lower, but, the annoyance value is relatively high, under low order resonance frequency excitation of 371 Hz, 460 Hz, and 492 Hz. Under the excitation of resonant frequencies such as 652 Hz and 813 Hz, the noise induced annoyance value is relatively low.
Keywords: gearbox;mode;sound quality;objective evaluation;subjective evaluation
2019, 45(8):19-24  收稿日期: 2018-07-05;收到修改稿日期: 2018-08-16
基金项目:
作者简介: 胡溧(1977-),男,湖北武汉市人,教授,博士,研究方向为汽车轻量化技术、汽车NVH及声品质
参考文献
[1] 贺岩松,涂梨娥,徐中明,等.汽车声品质研究综述[J].汽车工程学报, 2014(6):391-401
[2] 陈克,阳思远,毛书林.车内声品质主客观评价的相关性分析[J].沈阳理工大学学报, 2017(3):101-105
[3] HUANG H B, HUANG X R, LI R X, et al. Sound quality prediction of vehicle interior noise using deep belief networks[J]. Applied Acoustics, 2016, 113:149-161
[4] 严莉.关于车内声品质贡献分析与改善的测试技术研究[D].上海:上海交通大学, 2015.
[5] 胡腾.电动汽车声品质试验分析及研究[D].安徽:合肥工业大学, 2016.
[6] 蔡宣明,王俊元,马维金.重型汽车变速箱箱体有限元模态分析[J].机械设计与制造, 2011(1):22-24
[7] 秦真山. YC489柴油机噪声优化及声品质的研究[D].广西:广西大学, 2016.
[8] WANG Y S, SHEN G Q, XING Y F. A sound quality model for objective synthesis evaluation of vehicle interior noise based on artificial neural network[J]. Mechanical Systems and Signal Processing, 2014, 45:255-266
[9] MOSQUERA-SÁNCHEZ J A, SARRAZIN M, JANSSENS K A, et al. Multiple target sound quality balance for hybrid electric powertrain noise[J]. Mechanical Systems and Signal Processing, 2018, 99:478-503
[10] 马大猷.现代声学理论基础[M].北京:科学出版社, 2004:57-59.
[11] 高印寒,张澧桐,梁杰,等.基于客观心理声学参数的重型商用车车内异响噪声分析[J].吉林大学学报(工学版), 2016(1):43-49
[12] 左言言,张海峰,庄婷.车内声品质主客观评价模型对比分析[J].江苏大学学报(自然科学版), 2017(4):403-409