作者：穆瑞杰1,2, 谭继东2, 周进节1, 郑阳2, 朱雨虹2
作者单位：1. 中北大学机械工程学院，山西 太原 030051;
2. 中国特种设备检测研究院 国家市场监管总局无损检测与评价重点实验室，北京 100029
关键词：励磁频率优化;疲劳评估;磁巴克豪森噪声;铁磁性材料
摘要：
磁巴克豪森噪声在铁磁性材料早期疲劳损伤的检测中具有巨大的应用潜力。在疲劳检测过程中，励磁频率作为磁巴克豪森噪声的激发源，对检测结果有重要影响。实验研究励磁频率对磁巴克豪森噪声检测铁磁性材料疲劳时检测结果的影响规律，以20R钢材料为对象进行低周疲劳实验，并在励磁频率分别为9，16，35，60 Hz下对取自同一母材的3个试件进行疲劳过程中的磁巴克豪森噪声信号测量。实验结果表明，励磁频率较小时，3个试件测量结果分散，而当选择60 Hz励磁频率时，3个试件测量结果一致性良好；同时在60 Hz较高励磁频率下，疲劳过程中磁巴克豪森噪声信号幅值平均变化量是9 Hz较低励磁频率时的2.2倍。60 Hz较高励磁频率对材料的疲劳损伤程度的分辨力强，且分散度小。
Excitation frequency optimization for material fatigue inspection based on magnetic Barkhausen noise
MU Ruijie1,2, TAN Jidong2, ZHOU Jinjie1, ZHENG Yang2, ZHU Yuhong2
1. School of Mechanical Engineering, North University of China, Taiyuan 030051, China;
2. Key Laboratory of Nondestructive Testing and Evaluation for State Market Regulation, China Special Equipment Inspection and Research Institute, Beijing 100029, China
Abstract: Magnetic Barkhausen noise has great potential in early fatigue detection of ferromagnetic materials. In the process of fatigue detection, the excitation frequency, as the excitation source of magnetic Barkhausen noise, has an important influence on the detection results. The influence of excitation frequency on the fatigue detection results of ferromagnetic materials by magnetic Barkhausen noise was experimentally studied. The low-cycle fatigue experiment was carried out with 20R steel as the object, and the magnetic Barkhausen noise signal was measured in the fatigue process of three specimens from the same base material under the excitation frequency of 9, 16, 35, 60 Hz respectively. The experimental results show that when the excitation frequency is small, the measurement results of the three specimens are scattered. When the excitation frequency of 60 Hz is selected, the measurement results of the three specimens are in good consistency. At the same time, at a high excitation frequency of 60 Hz, the average amplitude variation of magnetic Barkhausen noise signal during fatigue is 2.2 times that at a low excitation frequency of 9 Hz. The high excitation frequency of 60 Hz has a strong resolution to the fatigue damage degree of the material, and the dispersion degree is small.
Keywords: excitation frequency optimization;fatigue assessment;magnetic Barkhausen noise;ferromagnetic material
2021, 47(2):92-97 收稿日期: 2020-06-01;收到修改稿日期: 2020-07-21
基金项目: 国家重点研发计划资助项目（2017YFF0209702）
作者简介: 穆瑞杰(1994-),男,山西大同市人,硕士研究生,专业方向为微磁多参数检测方法、疲劳检测
参考文献
[1] ZHENG X L. On some basic problems of fatigue research in engineering[J]. International Journal of Fatigue, 2001, 23(9): 751-766
[2] 许洋, 任尚坤, 张文君, 等. 基于磁导率方法的钢板裂纹检测[J]. 中国测试, 2020, 46(1): 34-38,70.
[3] REN S K, OU Y C, LI Y. Fatigue damage assessment for ferromagnetic items based on the metal magnetic memory technique[J]. Insight-Non-Destructive Testing and Condition Monitoring, 2011, 53(9): 494-496
[4] KOSTIN V N, VASILENKO O N. On new possibilities for making local measurements of the coercive force of ferromagnetic objects[J]. Russian Journal of Nondestructive Testing, 2012, 48(7): 401-410
[5] MOORTHY V. Important factors influencing the magnetic Barkhausen noise profile[J]. IEEE Transactions on Magnetics, 2016, 52(4): 1-13
[6] 孙俊杰, 王文涛, 邓重启, 等. 巴克豪森励磁检测传感器设计与仿真分析[J]. 传感器与微系统, 2018, 37(1): 105-107
[7] CHAVEZ-GONZALEZ A F, PEREZ-BENITEZ J A, ESPINA-HERNANDEZ J H, et al. Influence of frequency of the excitation magnetic field and material's electric conductivity on domain wall dynamics in ferromagnetic materials[J]. Journal of Magnetism and Magnetic Materials, 2016, 401(3): 287-295
[8] SINGH A, RAJA A R, YUSUFZAI M Z K, et al. Magnetic response of mild steel at various analyzing parameters[J]. Materials Today: Proceedings, 2019, 18: 3043-3051
[9] STUPAKOV O, MELIKHOV Y. Influence of magnetizing and filtering frequencies on Barkhausen noise response[J]. IEEE Transactions on Magnetics, 2014, 50(4): 1-4
[10] CHANG Y, JIAO J, LIU X, et al. Nondestructive evaluation of fatigue in ferromagnetic material using magnetic frequency mixing technology[J]. NDT & E International, 111: 102209.
[11] GRZEGORZ P, S AWOMIR W, PAOLO D B, et al. Multiple parameters fusion of electromagnetic nondestructive inspection data for evaluation of fatigue damage in steel elements[J]. International Journal of Applied Electromagnetics and Mechanics, 2018, 57: 1-8
[12] STUPAKOV A, PEREVERTOV A. Analog of the induction law for the magnetic Barkhausen noise[J]. Journal of Magnetism and Magnetic Materials, 2020, 498: 166238
[13] COLAIORI F. Exactly solvable model of avalanches dynamics for Barkhausen crackling noise[J]. Advances in Physics, 2008, 57(4): 287-359
[14] WILSON J W, ALLEN D J, PEYTON A J, et al. Detection of creep degradation during pressure vessel testing using electromagnetic sensor technology[J]. Materials at High Temperatures, 2017, 34: 448-457
