作者：张俊, 彭伟, 涂景怀, 程杰, 杨鹏, 吴瀚, 赵雪琳

作者单位：中国电子科技集团公司第二十四研究所, 重庆 400060

关键词：非侵入式电流传感器;双芯线;开气隙磁芯;磁阻传感器

摘要：

采用需求响应电力监控系统管理终端用电量，可提高智能电网运行效率。电流传感器是监控系统的关键组成之一，但传统的单芯线电流传感器不适用于终端设备双芯线电流的非侵入式检测。该文提出一种非侵入式双芯线电流传感器，采用环电线的开气隙磁芯控制电流产生的磁场分布，通过4个磁阻传感器分别测量4处气隙磁场，共同求解双芯线电流以及双芯线绕中轴旋转角度。使用时传感器扣合在被监测双芯线外包层,无需任何对准过程,可实现任意轮廓双芯线电流的非侵入式检测。实验表明：该传感器在0～20 A量程内的非线性度为1.5%，电流测量误差不超过1.8%。

Development of nonintrusive current sensor for two-wire power cords

ZHANG Jun, PENG Wei, TU Jinghuai, CHENG Jie, YANG Peng, WU Han, ZHAO Xuelin

No. 24 Research Institute of China Electronics Technology Group Corporation, Chongqing 400060, China

Abstract: Deployment of demand response electricity monitoring systems to manage end-use of electric power is an effective way to improve operating efficiency of the smart grid. Current sensor is one of the key components in the system. However, current sensors for single-wire power cords can't detect current nonintrusively in two-wire power cords connected to end-use appliances. This paper presented a nonintrusive current sensor for two-wire power cords, which used a gapped magnetic core surrounding the power cord to constrain the distribution of the magnetic field generated by the current. The magnetic fields in four air gaps were respectively measured by four magnetoresistive(MR) sensors. The current in the power cord and the rotation angle of the power cord around its central axis were calculated together by four MR sensors. The sensor embraced the monitored power cord in operation without any alignment process, and can detect current nonintrusively in two-wire power cords of any profile type. The experimental results show that the nonlinearity of the sensor is ±1.5% for the current range from 0 to 20 A with the maximum error limited to ±1.8%.

Keywords: nonintrusive current sensor;two-wire power cord;gapped magnetic core;magneto-resistive sensor

2018, 44(5): 71-76  收稿日期: 2017-10-10;收到修改稿日期: 2017-12-09

基金项目: 

作者简介: 张俊(1985-),男,重庆市人,助理工程师,硕士,主要从事电子器件测试工作。

参考文献

[1] PALENSKY P, DIETRICH D. Demand side management:Demand response intelligent energy systems, and smart loads[J]. IEEE Trans Ind Inform,2011,7(3):381-388.
[2] LU D, WEN Y M, LI P, et al. Self-contained self-powered wireless sensing node for AC power supply cords monitoring[C]//PIERS Proceedings,2013:12-15.
[3] YAMASHITA T, ZHANG Y, OKADA H, et al. Thin film based flexible current clamp sensor for green wireless sensor networks[C]//Proc. IEEE Sensors,2014:742-745.
[4] WEI P, CHENG C, WANG X F, et al. A high-performance hybrid current transformer based on a fast variable optical attenuator[J]. IEEE Trans Power Deliv,2014,29(6):2656-2663.
[5] TAO T, ZHAO Z H, MA W M, et al. Precise mutual inductance analysis of a novel clasp Rogowski coil with symmetrical double-printed imprints[C]//Proc. 6th Int. Conf. Electromagn. Field Problems Appl. (ICEF),2012:1-4.
[6] ORR P, NIEWCZAS P, BOOTH C, et al. An optically interrogated rogowski coil for passive multiplexable current measurement[J]. IEEE Sensors J,2013,13(6):2053-2054.
[7] 文玉梅,孙登峰,李平,等. 自全式无线霍尔电流传感器[J]. 仪器仪表学报,2014,35(8):1700-1706.
[8] CHEN K L, CHEN N M. A new method for power current measurement using a coreless hall effect current transformer[J]. IEEE Trans Instrument Measure,2011,60(1):158-169.
[9] CHAN J Y C, TSE N C F, LAI L L. A coreless electric current sensor with circular conductor positioning calibration[J]. IEEE Trans Instrument Measure,2013,62(11):2922-2928.
[10] KANG M H, WANG Y L, REN L Y, et al. Design of vibration-insensitive sagnac fiber-optic current sensors using spun high-birefringence fibers[J]. Journal of Modern Optics,2014,61(4):1120-1126.
[11] PENG N, HUANG Y, WANG S B, et al. Fiber optic current sensor based on special spun highly birefringent fiber[J]. IEEE Photonics Technology Letters,2013,25(17):1668-1671.
[12] LELAND E S, SHERMAN C T, MINOR P, et al. A new MEMS sensor for AC electric current[C]//Proc. IEEE Sensors,2010:1177-1182.
[13] CHEN Y C, HSU W H, CHENG S H, et al. A power sensor tag with interference reduction for electricity monitoring of two-wire household appliances[J]. IEEE Trans Ind Electron,2014,61(4):2062-2070.