作者：郑从兴^1,2, 刘显贵¹, 穆劲松², 李奋杰¹

作者单位：1. 厦门理工学院机械与汽车工程学院, 福建 厦门 361024;
2. 厦门环境保护机动车污染控制技术中心, 福建 厦门 361024

关键词：轻型汽车;排放;NEDC;WLTC;相关性

摘要：

针对当前欧盟提出的轻型车测试循环工况WLTC和日益严格的法规要求，为验证WLTC与NEDC测试工况对汽车排放影响的差异性特点，分别基于上述两种循环工况采用BMD（部分流采样系统）进行排放对比试验。试验结果表明：在两种工况法中，THC排放速率相关性最好，相关系数r2达到0.95，NOx次之，r2为0.79，CO和CH4排放速率的相关系数r2分别为0.72和0.78，CO2最差，r2为0.67；两种不同供油模式以及两种不同排放水平对不同污染物排放速率相关性的影响不同，THC和CO2基本不受影响，CO和NOx影响较大；两工况冷启动阶段排放占比都较大，THC占94.7%，CH4占75.1%，CO占63.6%，NOx占65.1%，冷启动排放控制至关重要；高速度段WLTC工况下CO2占35.25%，NEDC工况下CO2占24.47%，未来CO2排放及油耗监管将会加强；可为正在制定的国VI排放标准提供参考。

Emission correlation test of WLTC and NEDC cycles

ZHENG Congxing^1,2, LIU Xiangui¹, MU Jingsong², LI Fenjie¹

1. School of Mechanical & Automotive Engineering, Xiamen University of Technology, Xiamen 361024, China;
2. Xiamen Environment Protection Vehicle Emission Control Technology Center, Xiamen 361024, China

Abstract: Comparative test is carried out using BMD under testing conditions WLTC and NEDC, in verification of influence disparities on vehicle emission under WLTC and NEDC, and in response to WLTC proposed by European Union and increasingly stringent laws and regulations at present. Results show that, under the two testing conditions, the emission rate of THC has the best correlation and r² reaches 0.95, NO_x takes the second place with r² reaching 0.79. r² of CO and CH₄ emission correlation are 0.72 and 0.78 respectively. CO₂ has the worst emission rate correlation with r² of 0.67. Two different fuel supply modes and emission levels show different influence on the correlation of emission rate of different pollutants. THC and CO₂ are barely affected, while CO and NO_x are greatly affected. Emissions under both testing conditions at the cold start stage account for a considerable proportion, 94.7% for THC, 75.1% for CH₄, 63.6% for CO, and 65.1% for NO_x. Thus cold start emission control is crucial. At a high speed period, CO₂ accounts for 35.25% under WLTC and 24.47% under NEDC. The administration of CO₂ emission and fuel consumption will be strengthened in the future. The result of this research serves as a reference for the making of national VI emission standards.

Keywords: light vehicle;emission;NEDC;WLTC;correlation

2016, 42(12): 22-28  收稿日期: 2016-01-29;收到修改稿日期: 2016-03-14

基金项目: 国家自然科学基金项目（61104225）

作者简介: 郑从兴(1992-),男,江西九江市人,硕士研究生,专业方向为汽车性能试验与检测。

参考文献

[1] 中国国家标准化管理委员会. 轻型汽车污染物排放限值及测量方法(中国第五阶段):GB/T 18352.5-2013[S]. 北京:中国环境科学出版社,2013.
[2] SUAREZ-BERTOA R, ZARDINI A A, LILOVA V, et al. Intercomparison of real-time tailpipe ammonia measurements from vehicles tested over the new Worldwide harmonized Light-duty vehicle Test Cycle(WLTC)[J]. Environ Sci Pollut Res,2014,3(5):45-50.
[3] 叶松,李玲,石则强,等. 轻型汽车排放试验循环对比研究[J]. 交通节能与环保,2014(3):34-38.
[4] 郭红松,孙龙,秦宏宇,等. 辛烷值改进剂和工况对GDI轻型车非常规排放的影响[J]. 小型内燃机与车辆技术,2014(5):72-76.
[5] CHOI K C, PARK J H, LEE J T, et al. Research on domestic driving pattern for international standardization of light-duty vehicles emission test method[J]. Korean Society of Transportation,2012(30):85-89.
[6] MOCK P, KUHLWEIN J, TIETGE U, et al. The WLTP:How a new test procedure for cars will affect fuel consumption values in the EU[J]. International Council on Clean Transportation,2014(9):35-47.
[7] MAROTTA A, PAVLOVIC J, CIUFFO B, et al. Gaseous Emissions from Light-Duty Vehicles:Moving from NEDC to the New WLTP Test Procedure[J]. American Chemical Society,2015,5(7):33-38.
[8] 陈桂生,赵晶,付志勇,等. 能力评定中相关性处理与结果可信性及建标经济性研究[J]. 中国测试,2015,41(5):36-39.
[9] 付海超,李昕晏,王建海,等. GDI与FPI汽油车颗粒排放特性的试验研究[J]. 汽车工程,2014(10):78-82.
[10] 葛蕴珊,杨志强,张学敏,等. 在用汽油车瞬态工况排放测试方法研究[J]. 汽车工程,2007(3):17-21.
[11] 许立兵,俞小莉,葛蕴珊. 用于测量轻型车超低排放的分流稀释气袋取样系统[J]. 汽车工程,2004(6):37-41.
[12] 丁焰,葛蕴珊,张学敏. 汽车简易工况法的相关性研究[J].环境科学研究,2009(9):45-49.