作者：祝加雄
作者单位：乐山师范学院物理与电子工程学院, 四川 乐山 614004
关键词：永磁同步电机;逆变器故障检测;电压畸变;时间分析
摘要：
针对永磁同步电机（PMSM）驱动系统中脉宽调制（PWM）电压源型逆变器（VSI）容易发生开路故障的问题，提出一种简单且低成本的开路故障检测方法。首先，对PWM逆变器中功率开关发生开路故障时引起的对应端电压变化进行分析，构建开路故障与各相电压波形畸变的关系模型。然后，通过观测各相的电压畸变，并与阈值进行比较来构建各相的布尔错误模型。最后，基于布尔错误模型和错误检测时间来检测故障状态并识别故障开关。同时对检测时间进行分析，避免故障误报。实验结果表明：该方法能够快速且有效地进行故障诊断，具有良好的可行性和实用价值。
PMSM inverter fault detection method based on voltage distortion observation
ZHU Jiaxiong
School of Physics and Electronic Engineering, Leshan Normal University, Leshan 614004, China
Abstract: To address the issue that the pulse width modulation(PWM) voltage source inverter (VSI) in driving system of permanent magnet synchronous motor(PMSM) is prone to the open-circuit fault, a simple and low-cost open-circuit fault detection method was proposed. Firstly, the voltage change of corresponding terminal caused by the open-circuit fault of power switch in PWM inverter was analyzed to build the relational model between open-circuit fault and voltage waveform distortion of each phase. Then, Boolean error model of all phases was built by observing the voltage distortion of each phase and comparing it with the threshold. Finally, the fault state was detected and fault switch was identified based on Boolean error model and error detection time. At the same time, the detection time was also analyzed to avoid the fault alarm. The test results show that this method can effectively and quickly carry out fault diagnosis. Thus, it is of excellent feasibility and practical value.
Keywords: PMSM;inverter fault detection;voltage distortion;time analysis
2017, 43(2): 113-118 收稿日期: 2016-07-03;收到修改稿日期: 2016-09-20
基金项目: 国家自然科学基金民航联合基金重点项目（U1233202/F01）；乐山市科技计划项目（14GZD016）
作者简介: 祝加雄(1980-),男,四川乐山市人,讲师,硕士,研究方向为电路故障检测、电机控制等。
参考文献
[1] 赵品志,杨贵杰,李勇. 五相永磁同步电动机单相开路故障的容错控制策略[J]. 中国电机工程学报,2011,31(24):68-76.
[2] 李冠雄,刘景林. 复励式无刷直流电机故障诊断研究[J]. 测控技术,2011,30(9):103-107.
[3] DUAN P, XIE K, ZHANG L, et al. Open-switch fault diagnosis and system reconfiguration of doubly fed wind power converter used in a microgrid[J]. Power Electronics IEEE Transactions,2011,26(3):816-821.
[4] ESTIMA J O, MARQUES C A J. A new algorithm for real-time multiple open circuit fault diagnosis in voltage-fed PWM motor drives by the reference current errors[J]. Industrial Electronics IEEE Transactions,2013,60(8):3496-3505.
[5] JUNG S M, PARK J S, KIM H W, et al. An MRAS-based diagnosis of open circuit fault in PWM voltage-source inverters for PM synchronous motor drive systems[J]. Power Electronics IEEE Transactions,2013,28(5):2514-2526.
[6] 邵英. 采用 Park变换感应电机转子复合故障检测[J]. 电机与控制学报,2010,14(3):57-61.
[7] 王强,王友仁,张子富,等. 无刷直流电机驱动系统逆变器的开路故障诊断[J]. 中国电机工程学报,2013,33(24):114-120.
[8] 尹忠刚,刘静,钟彦儒,等. 基于双参数模型参考自适应的感应电机无速度传感器矢量控制低速性能[J]. 电工技术学报,2012,27(7):124-130.
[9] JUNG S M, PARK C B, KIM J H, et al. Simple on-line observation and compensation of dead-time effects[J]. Computers in Railways XIV: Railway Engineering Design and Optimization,2014,135(4):37-45.
[10] SHAHBAZI M, POURE P, SADDATE S, et al. Survey of fault tolerant AC-DCAC converters for wind power energy conversion systems[C]//International Conference on Power and Energy Systems Lecture Notes in Information Technology,2012.
